Rebirth of the New Farmers in the 1980s

Wan Feng listened to Master Luo Zhongxing’s introduction to the engine. Sui Meng Novel Network ()

"This engine has a total of 1,560 parts, of which 563 are low-difficulty parts, 891 are medium-difficulty parts, and there are only more than 100 parts that are really difficult. Although it can be copied by hand, the speed is too slow. We can't make a few motorcycles in a month."

"Of course, we can't rely on our own production. We can't do everything professionally. We can't control the cost of our own production. We can't enter the market at all. Therefore, we have to contract all the parts with low processing difficulty to professional factories. To do it, just leave a few key things to make by ourselves. Then we can get the parts back and assemble them. This will not only speed up the production schedule but also greatly save costs."

Luo Zhongxing nodded, "Then we will specialize in the production of some of the most difficult things, so that others cannot produce them, and others have to imitate and conquer these technologies."

This is also the trick to guard against lazy people. With the technical content of the 50 engine, it is really not difficult if someone really wants to tinker.

"How long did the first unit burn when it ignited?"

"Unit 1 ignited twice, the first ignition worked for one minute and fifteen seconds, and the second ignition worked for five minutes."

"Do you put out the fire by yourself?"

"No, we found the problem and took the initiative to put out the fire, and then checked."

"What's the problem?"

"The first time the organism overheated, we found the reason and eliminated it and performed a second ignition. After five minutes of operation, the carburetor had a problem, which has now been eliminated."

"So now we should conduct a third test run to see if it can work for ten minutes, and if there are any problems."

Unit 1 was started for the third time, and the engine made a sudden working noise.

The technician stared nervously at the working engine.

One minute, three minutes, five minutes...

This time the engine worked longer than the previous two times, until the engine worked for about eight minutes, and the body overheated again.

Luo Zhongxing immediately issued the order to stop.

This time it took a long time to find the cause. After nearly a morning of unremitting efforts, I finally found the cause of the overheating phenomenon and the problem appeared on the piston ring.

Although the specifications of the piston rings worn by Master Luo himself meet the standards, the metal materials are not matched properly, and overheating and deformation will occur after long working hours.

They are not jobs that specialize in the production of this stuff, so a professional counterpart is needed.

"We are looking for a professional manufacturer to solve this problem." This is Luo Zhongxing's suggestion.

At that time, there was a manufacturer in Liaoyang and a manufacturer in Shijiazhuang.

Piston rings produced by Liaoyang manufacturers are low in cost, but have poor wear resistance.

The piston rings manufactured in Shijiazhuang are of high quality and long-lasting is a common choice for many engines today. The piston rings used in the single-cylinder 195 of the Wahou Machinery Factory are produced by this factory.

However, the Shijiazhuang factory definitely does not have piston rings for this 50 engine, because this thing is currently only produced by the Jialing factory, and they cannot travel all the way to Shijiazhuang to order piston rings.

This requires Shijiazhuang to make new molds. When people do not know the scale of the product, they may not be able to make them.

"Master Luo, it seems we have to go to Shijiazhuang."

Wan Feng decided to go to Shijiazhuang in person with Master Luo. At this time, he had to go out. When he was rich, he had to show the power of money. By the way, he would go to Qindao to do some personal affairs.

The motorcycle engine was temporarily put aside, Wan Feng pushed Luan Feng's motorcycle over, and a technician took the motorcycle and replaced the front wheel.

"How about the 1105 and 1115 engines now?" Wan Feng asked the two single-cylinder diesel engines with 18 and 25 horsepower.

"It has completely passed the national inspection, but we don't know what it should do now. Only a small amount was produced and then technically sealed." Xiao Dexiang explained.

"No hurry, let me think about it. What should I use them for? After the motorcycle engine research is successful, we should study the four-cylinder engine next."

Those two single-cylinder high-horsepower diesel engines are of course used on large-tonnage agricultural tricycles.

However, if this kind of agricultural tricycle is put into production, it will inevitably have an impact on the four wheels. The four wheels of the machinery factory are now in short supply, and there is no need to put into production of large tonnage tricycles for the time being.

Let's do technical reserves for two years first.

Anyway, those in Dongshan Province when the wind is the five-star superpower, I still don't know where the cyclone is blowing.

"We have been researching according to the working principle diagram you drew. We have cast the machine body and bought all the parts that can be purchased. We plan to produce the parts that are not for sale, and we have already stocked them. "

Wan Feng was once again shocked by the enthusiasm of these people.

Are these people working on four-cylinder diesel engines while working on 50 engines? What spirit is this?

Is this the spirit of serving the RMB wholeheartedly...for the people?

At this moment, Wan Feng suddenly felt that it was time for his mother to go out to find her two brothers and aunts, and it was time to get back.

The working environment and people's enthusiasm for work inspired him.

If it weren't for the talents he was thinking about Maozi and some of the skills he wanted ~www.NovelMTL.com~ he would want to come back now.

This is a place for people to do something.

The front fork and front wheel of the motorcycle were quickly replaced. Xiao Dexiang rode out for a lap of addiction. When he came back, Wan Feng was already working on the electric fan.

He is working with people in the technical department to study how large a coil should be wound as the starting source of the fan.

There are many people, and the coils are wound around the coils, and the fan blades are used as fan blades. It didn't take long for a fan without an outer package to be successfully produced. When the power supply was connected, the fan began to spin.

Although the workshop can block the shade, it can't block the high temperature. With such a thing, everyone makes do with the fan.

"It's still a good thing. The production of this thing is so simple. Why don't we produce some and sell it?" a technician asked.

Wan Feng said, “I’m afraid it’s too late this year. It’s the end of July. What we produce and pass the inspection will probably be in the fall. Next year, we can set up an electrical appliance factory to produce these things. If you want to sell it, it won’t work if you don’t shake your head and cannot adjust the wind speed regularly.”

"That's not a problem. We can make a small mechanical device without shaking our heads. As for the timer on the washing machine, can't it be done?" Another technician who had seen the washing machine suggested.

"Whether we have to study the washing machine, it seems that it's not great to carry a motor under that thing."

It's okay if the technician didn't suggest it. As soon as he suggested that these people had an idea about the washing machine.

Wan Feng hurriedly took the fan like a skeleton frame and rode home on a motorcycle. After sitting here for a while, they were uncertain about what they wanted to make. These guys seemed to have become madmen.

.